1-20 ton gas/oil fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2 Mpa
Fuel: Nature gas, coke oven gas, biogas, methanol, liquid propane gas, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, chemical, food, textile, printing and dyeing, cigarettes and tobacco, fodder, pharmacy, building materials, brewery, rubber, hospital etc.
7-70 MW gas/oil fired hot water boiler
Capacity: 7-70 MW
Pressure: 1.0-1.6 Mpa
Fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, LPG, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, hospital, colleges and universities.
2.8-29mw coal fired boiler
Pressure: 1.0-1.25 Mpa
Fuel: Bituminous coal, lean coal, anthracite
Industries: Heating, hotels, schools, hospitals
horizontal thermal fluid heater
Capacity: 700 - 14000 kw
Pressure: 0.8 - 1.0 Mpa
Fuel: natural gas, coke oven gas, bio-gas，liquid propane gas, diesel, heavy oil, light oil, crude oil
Industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries
1-20 ton biomass fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2.5 Mpa
Fuel: Biomass particles
Industries: Heating, chemical, food, tobacco, textile, printing and dyeing, feed, medicine, building material, wine, rubber, hospital
(PDF) Efficient cogeneration scheme for sugar industry - ResearchGate
which is mostly used as a captive boiler fuel and as a. raw material in about 6.5 TPH (tones per hour) steam @ 21 ata for two. mills and 4.5 In a sugar mill, steam turbines are typically single. stage impulse . Main drive efficiency, % 35 90.
Boiler - EEAS
Oct 4, 2012 Bagasse Quantity. TPH. 43.51. 46.18. 41.78. 42.89. 41.2. 42.2. 38.6. Steam /Fuel ratio 90% of sugar mill boilers in Thailand are below this category. 9 35 kWH. 280 kg. Bagasse. Sugar Mill. High Pressure Boiler and TG.
Modification of Co-Generation Plant in a Sugar Cane Factory for
The energy is supplied to the sugar cane factory mainly as fuel or bagasse to The power house typically incorporates a steam boiler and a back-pressure . consumption per mill (average load of 300 kW) was about 7.5 TPH steam at 15 ATA. single stage impulse type steam turbines have very low efficiencies of 35%.
boiler design and selection in the cane sugar industry - CiteSeerX
In a sugar factory steam is used primarily for: (a) Generating raw sugar factory the quantity of bagasse available should be just .. unit is disposed of while the boiler is on range through collectors in the 35 MAIN STEAM STOP. 3 6. - ".
Final_report - SlideShare
Jan 6, 2017 REPORT ON PROCESS OVERVIEW OF GOBIND SUGAR MILLS LTD. This Boiler has a steam generating capacity of 1 x 150 TPH operating 32 Manual dampers provided in the pneumatic 35 The silo is fuel storing
Development and Installation of High Pressure Boilers for Co
Keywords: High Pressure Boiler, Co-Generation Plant, Sugar Industries, Steam Turbine, Boilers 2 numbers of 70 TPH, 67 ATA Multi fuel fired boilers.
Waste heat recovery - Alfa Laval
Process heat is usually generated in steam boilers and/or in fired heaters/furnaces. . coke oven gas refining, and sugar-based ethanol production, combustible .. to 7.5 tph (16,530 lb/h), equalling a 35%40% reduction of fresh steam.
Sugar Plant | Ayoki Fabricon Pvt Ltd | Service Provider in Doleh Patil
Erection of complete 2500 TCD Sugar Plant, including 2 x 35 TPH Boilers and connected piping at Shivaji Rao Patil . Super Steam Boiler Engineers Pvt. Ltd.
Project Opportunity Fact Sheet: The Central Azucarera Don - Giz
Use of bagasse and filter mud from sugar mills for energy (the extraction of the sugar juice) is burnt in boilers, where steam is produced to run total steam demand lies at 300 tph (tons per hour, installed capacity is 436 capacity to 35 MW at a medium pressure level and up to maximum 60 MW if a high pressure level is.
Bagasse based Co-generation Project at Titawi Sugar Complex - SGS
Under present arrangement, heat and power requirement at the Titawi Sugar Complex is . The plant is designed to operate with boiler outlet steam configuration of 86 kg at 90 Tonne Per Hour (TPH) nominal capacity boiler with the super heater page 35. This template shall not be altered. It shall be completed without